Product ID:37 589J1A MILP24441/4 R153 TYI
MSDS Date:04/25/1988
FSC:8010
NIIN:00-410-8464
Kit Part:Y
MSDS Number: BGWRH

VALSPAR CORP, THE

1101 THIRD ST S
MINNEAPOLIS, MN 55415-1211
US

Emergency Phone: 612-332-7371

Info Phone: 612-332-7371

Cage: 23526

VALSPAR CORPORATION

MINNEAPOLIS, MN 55415 US

Telephone: 612-332-7371/888-345-5732

Cage: 23526

N-BUTYL ALCOHOL (SARA III)

CAS: 71-36-3

RTECS: EO1400000

Fraction By Weight: 35%

OSHA PEL 100 PPM

ACGIH TLV: S, C 50 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TALC (CONTAINING NO ASBESTOS)

CAS: 14807-96-6

RTECS: WW2710000

Fraction By Weight: 40%

OSHA PEL 2 MG/M3 RDUST

ACGIH TLV: 2 MG/M3 RDUST; 9192

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: 1 - 5%

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3; 9192

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: <1%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

AMIDO-AMINE-RESIN

CAS: 68443-08-3

TETRAETHYLENEPENTAMINE

CAS: 112-57-2

RTECS: KH8585000

Fraction By Weight: <1%

ACGIH TLV: 2 PPM

POLYAMIDE RESIN

CAS: 68410-23-1

Fraction By Weight: 20%

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE IRRITATION. CAN BE ABSORBED
THROUGH THE SKIN. HARMFUL IF INHALED. MAY AFFECT THE BRAIN, NERVOUS
SYSTEM OR RESPIRATORY SYSTEM. MAY CAUSE NOSE AND THRONIC: POSSIBLE
PERMANENT ABRAIN AND NERVO US SYSTEM DAMAGE OR DEATH.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:MAY CAUSE DIZZINESS, HEADACHE, NAUSEA OR
RESPIRATORY IRRITATION.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, LIVER,
KIDNEY OR RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.

First Aid:INHALATION: REMOVE TO FRESH AIR. IF NOT BREATHING GIVE CPR.
CALL A PHYSICIAN. EYE: IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER
FOR 15 MINUTES. CALL A PHYSICIAN. SKIN: WASH WITH PLENTY OF SOAP &
WATER. INDUCE VOMITING. IF CONSCIOUS, GIVE 2 GLASSES OF WATER TO
DRINK. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. CALL A PHYSICIAN.

Flash Point Method:TCC
Flash Point:99.0F,37.2C
Lower Limits:1
Upper Limits:11
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER SPRAY TO COOL
SURROUNDING CONTAINERS.
Unusual Fire/Explosion Hazard:NONE

Spill Release Procedures:VENTILATE AREA. AVOID BREATHING OF VAPORS. USE
SCBA OR AIRMASK FOR LARGE SPILLS IN A CONFINED AREA. ELIMINATE
IGNITION SOURCES. REMOVE WITH INERT ABSORBENT AND NON-SPARKING
TOOLS. AVOID ALL PERSONAL C ONTACT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE BELOW 120F IN A DRY, WELL
VENTILATED AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE.
KEEP AWAY FROM HEAT, SPARKS AND OPEN FLAMES.
Other Precautions:DO NOT CUT, PUNCTURE OR WELD ON OR NEAR CONTAINER.
ALL LABEL WARNINGS MUST BE OBSERVED UNTIL THE CONTAINER HAS BEEN
CLEANED OR RECONDITIONED. CONTAINERS SHOULD BE GROUNDED WHEN
POURING. AVOID FREE FAL L OF LIQUID IN EXCESS OF A FEW INCHES.

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE NIOSH/MSHA APPROVED RESPIRATORS AS
PER CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND
NIOSH-RESPIRATOR DECISION LOGIC-PUBL ICATION NUMBER 87.108.
Ventilation:PROVIDE SUFFICIENT LOCAL EXHAUST VENTILATION FOR SPRAYING
OR USE IN A CONFINED AREA.
Protective Gloves:NEOPRENE RUBBER FOR PAINT APPLICATION.
Eye Protection:SAFETY PAINT GOGGLES
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING, APRON AND OTHER USUAL CLOTHING USED
IN PAINTING.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
DO NOT GET ON SKIN, IN EYES OR ON CLOTHING. DO NOT BREATHE VAPORS OR
MISTS.

HCC:F3
Boiling Pt:B.P. Text:243.0F
Decomp Temp:Decomp Text:>300F,>149C
Vapor Pres:2.6
Vapor Density:2.6
Spec Gravity:1.22
Evaporation Rate & Reference:0.5 (N-BUTYL ACETATE = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK EPOXY PAINT, TYPICAL PAINT ODOR
Percent Volatiles by Volume:53.4

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:AMMONIA COMPOUNDS, SILICON DIOXIDE,
NITROGEN OXIDES, METAL OXIDES, CARBON MONOXIDE, CARBON DIOXIDE

Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN CHEMICAL DISPOSAL
AREA IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND LOCAL
LAWS AND REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.